GRC構件實際上分為好幾種的種類，其中GRC線條還是比較常用到的材料，重量輕，一個人即可以隨意搬動、施工。粘貼牢固，具有較高的裝飾價值。那么GRC線條的各種情況下的處理方法是什么內容呢？
GRC components are actually divided into several types. Among them, GRC lines are commonly used materials with light weight. One person can move and construct at will. It is firmly pasted and has high decorative value. What are the processing methods of GRC lines in various cases?
GRC線條基層處理
GRC line base treatment
在GRC線條的基礎處理過程中，其他施工程序，如墻體、門窗洞口的施工安裝等，必須已經完成并驗收。
During the foundation treatment of GRC lines, other construction procedures, such as the construction and installation of walls, door and window openings, must have been completed and accepted.
GRC線條基清洗：清理混凝土墻上殘留的浮灰、脫模劑油漬等雜物和抹灰空心部位。
GRC line base cleaning: clean the residual floating ash, release agent, oil stain and other sundries on the concrete wall and the plastered hollow parts.
要求粘貼的聚苯板表面平整度偏差不得超過4mm。超過偏差時，應打磨突出的壁。補凹處保證整面墻的平整度在4mm以內，陰陽角方正，上下光滑的。
The surface flatness deviation of polystyrene board required to be pasted shall not exceed 4mm. When the deviation is exceeded, the protruding wall shall be polished. The concave part shall ensure that the flatness of the whole wall is within 4mm, the internal and external corners are square and smooth up and down.
墻體接縫處的劈裂混凝土塊、夾雜物、空心鼓等，重新修補；窗臺的懸垂部分用2%的水泥砂漿傾斜，外墻的各種開口都被填滿。
Remove the split concrete blocks, inclusions and hollow drums at the wall joints and repair them again; The suspended part of the window sill is inclined with 2% cement mortar, and various openings of the outer wall are filled.
GRC線條的硬化處理
Hardening of GRC lines
GRC線條主要由脫模的B2級防火聚苯乙烯組成，粘貼耐堿玻璃纖維網，并復合有特殊的粘合外保護層。硬化后結合了有機材料的柔韌性和水泥的強度。GRC線條既隔熱又輕便，形狀穩定，不受溫度變化影響，耐寒，耐熱；不受潮濕氣候和酸雨的影響。
GRC line is mainly composed of demoulded B2 grade fireproof polystyrene, pasted with alkali resistant glass fiber mesh, and compounded with special adhesive outer protective layer. After hardening, it combines the flexibility of organic materials with the strength of cement. GRC lines are heat-insulating and light, stable in shape, not affected by temperature changes, cold and heat resistant; Not affected by humid climate and acid rain.
GRC線條防火不排放有毒物質，是的產品。GRC的種類和型號很多（如線條、羅馬柱、保溫板、花飾等），可以安裝在窗、門、廳柱、檐角、墻體四個側面；它也可以在外部噴涂單獨的油漆顏色。還可以使人造石的文化效果，使建筑的立面更加美觀，給建筑師帶來新的不一樣的想法。
GRC line fire prevention does not discharge toxic substances. It is a high-quality product of environmental protection. There are many types and models of GRC (such as lines, roman columns, insulation boards, flower decorations, etc.), which can be installed on the four sides of windows, doors, hall columns, eaves corners and walls; It can also be painted with a separate paint color on the outside. It can also make the cultural effect of artificial stone, make the facade of the building more beautiful, and bring new and different ideas to architects.
山東GRC構件廠家提醒，GRC線條安裝注意事項也要注意，比如安裝、切割GRC線條前，墻面不需灑水濕潤，粉塵、污漬等影響粘結強度雜物應清理干凈。拼裝時，拼裝縫應盡量留于整根GRC構件中間部位。粘結GRC線條時，砂漿用水按加水量進行。但拼接時砂漿加水量應較用量在1～2%。剛粘結的GRC線條應注意保養，防止雨水沖刷、人為損壞等。
Shandong GRC component manufacturer reminds that the precautions for GRC line installation should also be paid attention to. For example, before installing and cutting GRC lines, the wall does not need to be watered, and the sundries affecting the bonding strength such as dust and stains should be cleaned up. During assembly, the assembly joint shall be reserved in the middle of the whole GRC component as far as possible. When bonding GRC lines, water for mortar shall be added according to the recommended amount of water. However, the amount of mortar added during splicing shall be 1 ~ 2% higher than the recommended amount. The GRC lines just bonded shall be maintained to prevent rain erosion, man-made damage, etc.
Using GRC lines is a better choice without emitting toxic substances. It is an environmentally friendly high-quality decorative building materials product. So if you have needs, you can follow our website and ask questions.
